2016 Dynamax Force Brake Controller wiring, where is it ?

[724Bravo]

2016 Dynamax Force Brake Controller ?

I can't seem to find the Brake Controller Wiring Harness under the dash.
Do I have to disassemble the dash to find it ?
Any help would be appreciated.

Thanks

[BLK-9]

I think Halla indicated in a previous post it was located under the drivers seat. I'm sure he will chime in soon to validate the location.

[FOURWHL]

It's sitting on the gas tank below the cab on the drivers side. You have to pull a panel to get to it and then run it through the firewall.

[halla]

Yes gas tank below the drivers side. If you lay under the coach you can find red wire looms in the frame. I fed the cable through those, in through the firewall and hooked it all up.


2016 Dynamax Force. Just-Rite2

[FOURWHL]

Originally Posted by halla

Yes gas tank below the drivers side. If you lay under the coach you can find red wire looms in the frame. I fed the cable through those, in through the firewall and hooked it all up.


2016 Dynamax Force. Just-Rite2

Good idea!

Also there's room in the air brake panel knockouts in the firewall, which is what I used.

[BLK-9]

I found wire coiled up on top the drivers side fuel tank, but bringing/feeding it in through the air brake firewall is confusing to me. would you happen to have a picture available?

[FOURWHL]

Not near my RV so can't grab a pic.

Are you a Force or Force HD? Would probably be a bit different if you don't have air brakes.

[Kenny kustom]

All the force models have air brakes.


2016 Sabre 36QBOK
2015 Ram 3500 CUMMINS

[halla]

See the green, red tubes. This is on the drivers side left of the wire looms.




2016 Dynamax Force. Just-Rite2

[724Bravo]

Originally Posted by halla

See the green, red tubes. This is on the drivers side left of the wire looms.

Attachment 108529
2016 Dynamax Force. Just-Rite2

Is that the BC Loom in the Red spiral rap ?

Is the BC wiring separate from the rest of the trailer wiring or is it all together in one wiring loom ?

[halla]

No. I used heat shrink wrap. The wires were out of loom by that point.


2016 Dynamax Force. Just-Rite2

[BLK-9]

Originally Posted by FOURWHL

Not near my RV so can't grab a pic.

Are you a Force or Force HD? Would probably be a bit different if you don't have air brakes.

Force HD

[halla]

Should all have air brakes. Mine is a Force. Force HD is same as DX3


2016 Dynamax Force. Just-Rite2

[FOURWHL]

Ok yeah then trace the colorful tubes under the dash. They'll go through a plastic piece in the firewall with knockouts for other tubes/wires. I used one of these rather than drilling my own hole