|
07-14-2019, 03:53 PM
|
#1
|
Junior Member
Join Date: Jul 2019
Posts: 4
|
Fuse keeps popping
FlagStaff 625D pop up camper. The second fuse down from top keeps popping and can’t figure it out. I think it operates the ceiling lights and fan. I do not have the information as to the right Amps for these fuses so maybe that is my error too.
In order from top to bottom I have:
15 Amp
15 Amp
25 Amp
25 Amp
30 Amp
Please help! This is very frustrating.
|
|
|
07-14-2019, 04:15 PM
|
#2
|
Site Team
Join Date: Oct 2014
Posts: 15,302
|
15A should be OK for lights and a small fan. What is running when the fuse blows. If nothing on, look for a shorted or damaged wire as some of the wires run through the lifts.
__________________
2015 Freedom Express 248RBS
TV 2015 Silverado HD2500 Duramax
TST Tire Monitors
Honda 2000I + Companion
2 100W solar panels
|
|
|
07-14-2019, 04:33 PM
|
#3
|
Junior Member
Join Date: Jul 2019
Posts: 4
|
There is nothing on that we are aware of except the fridge.
Perhaps one of the ceiling light are on but I can’t tell.
Would it have anything to do with any of the switches outside. The panels located near the refrigerator. We have had this camper for awhile but had a very poor tutorial on how to use it.
We have had issues with the lights before and just had a new roof put on this winter. We had them check the lights and they reported they were all working. Bad light bulbs wouldn’t cause the fuse to pop? I have limited knowledge when it comes to electric and wiring.
We have checked the switch under the sink too.
__________________
Gary
2008 FlagStaff 625D
|
|
|
07-14-2019, 04:48 PM
|
#4
|
Site Team
Join Date: Oct 2014
Posts: 15,302
|
Ahh. New roof. The wiring for the lights and fan run through the roof and down one of the lifts. it is possible that a wire is pinched and there is a short. When you say trouble with lights, what trouble. Does the fuse blow instantly or does it last a while.
__________________
2015 Freedom Express 248RBS
TV 2015 Silverado HD2500 Duramax
TST Tire Monitors
Honda 2000I + Companion
2 100W solar panels
|
|
|
07-14-2019, 05:31 PM
|
#5
|
Junior Member
Join Date: Jul 2019
Posts: 4
|
Currently it blows instantly when we moved the sink into position. Prior to installing the new battery we unplugged everything, put new fuse installed new battery then plugged in to 30 Amp shore line and heard it pop again.
Prior to the new roof we were having light trouble too. Outlets worked but no inside lights or fan. Then after being plugged in for a day while camping the lights mysteriously came on then if you turned another light on they would go off and not come on again. We have tried to look at our he wiring but don’t see where it is noticeably pinched. That is why when the new roof was put on we specifically asked them to also check the lights. They reported they were all working.
We have been looking for a reset button near the battery that we saw in an older post but have not located it yet. going to call it quits for today. Plan on calling the roof people tomorrow.
Thank you for taking the time to try and help us.
With the new battery now hooked up we here a fan running near or inside the breaker box. In the past we only occasionally heard this fan intermittently. Will this run all the time or is it trying to charge something and will stop.
It’s all a little confusing.
__________________
Gary
2008 FlagStaff 625D
|
|
|
07-14-2019, 05:33 PM
|
#6
|
Site Team
Join Date: Jan 2007
Location: Goodyear, Arizona
Posts: 33,855
|
Possible bad plunger switch?
__________________
Dan-Retired California Firefighter/EMT
Shawn-Musician/Entrepreneur/Wine Expert
and Zoe the Wonder Dog(R.I.P.)
2016 PrimeTime TracerAIR 255, pushing a 2014 Ford F150 SCREW XTR 4x4 3.5 Ecoboost w/Max Tow Package
4pt Equal-i-zer WDH and 1828lbs of payload capacity
|
|
|
07-14-2019, 11:06 PM
|
#7
|
Senior Member
Join Date: Aug 2018
Location: Northwest Indiana
Posts: 572
|
Fan will run when there is a load on it. When I turn on a lot of lights with a fully charged battery, only then will the fan turn on. If the battery needs charging, fan comes on as soon as I plug the camper in.
Definitely sounds like a bad connection or cut wiring with lights turning on and off by themselves, that could be causing a short.
Just so you know, troubleshooting electrical problems can be very costly because of the time involved. Only use a qualified, TRUSTWORTHY tech, as they could lengthen the time in finding the problem, just to make as much money as possible.
I don't recommend inexperienced or unknowledgeable people to play with wiring or electricity.
Good luck finding your issue
__________________
2024 Black Jeep Grand Cherokee L Altitude 4WD, 121" WB, 3.6L, 8 speed, Blacked Out Package, 265/50R20 wheels, 6,200# Tow Rating, pulling a 2020 Rockwood Premier 2716G Pop Up, with a 14' box. Go through Indiana Dunes NP 5X/week! Previously had 2012 Jayco Jay Flight 26BH and 2008 Jayco Jay Flight 19BH Travel Trailers. Also previously had 2007 Starcraft 2406 Pop Up with 12' box and bathroom, Previously had 2005 Rockwood 2290 Pop Up with 12' box and porta potty cabinet.
|
|
|
07-15-2019, 05:34 AM
|
#8
|
Senior Member
Join Date: Mar 2014
Posts: 3,098
|
Quote:
Originally Posted by GFR
Currently it blows instantly when we moved the sink into position. Prior to installing the new battery we unplugged everything, put new fuse installed new battery then plugged in to 30 Amp shore line and heard it pop again.
Prior to the new roof we were having light trouble too. Outlets worked but no inside lights or fan. Then after being plugged in for a day while camping the lights mysteriously came on then if you turned another light on they would go off and not come on again. We have tried to look at our he wiring but don’t see where it is noticeably pinched. That is why when the new roof was put on we specifically asked them to also check the lights. They reported they were all working.
We have been looking for a reset button near the battery that we saw in an older post but have not located it yet. going to call it quits for today. Plan on calling the roof people tomorrow.
Thank you for taking the time to try and help us.
With the new battery now hooked up we here a fan running near or inside the breaker box. In the past we only occasionally heard this fan intermittently. Will this run all the time or is it trying to charge something and will stop.
It’s all a little confusing.
|
I also suspect a problem in the roof wiring. There is a plunger switch that allows current to the roof lights and roof fan that activates when you raise the galley into position. This would explain the fuse blowing when you raise the sink into position. The problem could be at the plunger switch, or further up the roof.
Loose connections, frayed or cut wires touching are most likely explanations for the problems you have been having. Turning off (or disconnecting if there is no switch) each light individually may help you isolate the specific wires causing trouble.
I have never heard of a reset switch near the battery. There is often a cut-off switch to isolate the battery when your pop-up is being stored. This prevents the battery being run down while in storage due to the CO/propane detector, stereo, etc. The cut-off switch is owner or dealer installed, the factory doesn't put one in.
120V outlets are completely separate from your lights, which run on 12V. 12V is supplied by the converter when plugged in, and by the battery when not.
The converter cooling fan comes on when the converter is under significant load. Charging a new battery (it probably was NOT fully charged when you brought it home) could keep the fan running for 5-6 hours, especially if it's hot inside the camper.
hope this helps
Fred W
2019 Flagstaff T21TBHW A-frame
2008 Hyundai Entourage minivan
camping Colorado and adjacent states one weekend at a time
|
|
|
07-15-2019, 08:07 AM
|
#9
|
Just as confused as you
Join Date: Aug 2013
Location: south central Wisconsin
Posts: 5,108
|
OP is probably referring to the resettable 12vdc breaker/fuse on the front hitch a-frame. The little black button on the side is the reset.
Though this resettable fuse is not the cause of his problem. If it trips he will not have any power from the battery when boondocking. The battery will not recharge when he's on shore power but he will have 12vdc power to the lights and fan from the converter.
__________________
Richard & Jill
2014 Flagstaff 832IKBS Classic Super Lite
2018 Silverado 1500 Crew Cab Z71 4WD All Star Edition
Camping since 1989, Seasonal since 2000.
Car Shredder Op/Tech, Scrap Metal Recycling - retired
|
|
|
07-15-2019, 08:10 AM
|
#10
|
Site Team
Join Date: Mar 2014
Location: Grayson County, Texas
Posts: 21,587
|
Quote:
Originally Posted by Scrapper
OP is probably referring to the resettable 12vdc breaker/fuse on the front hitch a-frame.
|
Probably not if the OP states " The second fuse down from top keeps popping and can’t figure it out. I think it operates the ceiling lights and fan. I do not have the information as to the right Amps for these fuses so maybe that is my error too.
In order from top to bottom I have:
15 Amp
15 Amp
25 Amp
25 Amp
30 Amp"
... and lists the amperage of fuses in the fuse panel.
__________________
2015 FR Wildcat 295RSX / GMC Sierra
Nights Camped: '13 = 49/'14 = 74/'15 = 74/'16 = 85/'17 = 110/'18 = 111/'19 = 86/'20 =108/'21 = 115/'22 = 135/'23 = 78; Booked for 2024 = 69
|
|
|
07-15-2019, 08:58 AM
|
#11
|
Just as confused as you
Join Date: Aug 2013
Location: south central Wisconsin
Posts: 5,108
|
Quote:
Originally Posted by Mr. Dan
Probably not if the OP states "The second fuse down from top keeps popping and can’t figure it out. I think it operates the ceiling lights and fan. I do not have the information as to the right Amps for these fuses so maybe that is my error too.
In order from top to bottom I have:
15 Amp
15 Amp
25 Amp
25 Amp
30 Amp"
... and lists the amperage of fuses in the fuse panel.
|
What I was responding to is the statement OP made in post #5. - Quote " We have been looking for a reset button near the battery that we saw in an older post but have not located it yet. going to call it quits for today. Plan on calling the roof people tomorrow"
pgandw then replys in post #8, - Quote " I have never heard of a reset switch near the battery. There is often a cut-off switch to isolate the battery when your pop-up is being stored. This prevents the battery being run down while in storage due to the CO/propane detector, stereo, etc. The cut-off switch is owner or dealer installed, the factory doesn't put one in."
__________________
Richard & Jill
2014 Flagstaff 832IKBS Classic Super Lite
2018 Silverado 1500 Crew Cab Z71 4WD All Star Edition
Camping since 1989, Seasonal since 2000.
Car Shredder Op/Tech, Scrap Metal Recycling - retired
|
|
|
07-15-2019, 09:42 AM
|
#12
|
Site Team
Join Date: Mar 2014
Location: Grayson County, Texas
Posts: 21,587
|
Quote:
Originally Posted by Scrapper
What I was responding to is the statement OP made in post #5. - Quote "We have been looking for a reset button near the battery that we saw in an older post but have not located it yet. going to call it quits for today. Plan on calling the roof people tomorrow"
pgandw then replys in post #8, - Quote "I have never heard of a reset switch near the battery. There is often a cut-off switch to isolate the battery when your pop-up is being stored. This prevents the battery being run down while in storage due to the CO/propane detector, stereo, etc. The cut-off switch is owner or dealer installed, the factory doesn't put one in."
|
Got it. Since you didn’t use the Quote function, I guessed wrong about the post to which you were referring. Sorry.
__________________
2015 FR Wildcat 295RSX / GMC Sierra
Nights Camped: '13 = 49/'14 = 74/'15 = 74/'16 = 85/'17 = 110/'18 = 111/'19 = 86/'20 =108/'21 = 115/'22 = 135/'23 = 78; Booked for 2024 = 69
|
|
|
07-15-2019, 10:37 AM
|
#13
|
Bob414
Join Date: Jan 2019
Location: VA
Posts: 99
|
I read the OP changed the battery. Fuses will blow is not correctly reconnected. Check the polarity.
I have had a incandescent bulb fail in such a way that shorted the lights on a car. The filament burned out and caused the post in the bulb to fall against the other post inside the bulb. Only seen once in 50 years of owning cars.
Led bulbs, I have not heard of a short blowing fuses. Normally bulb shorts, burn the short path out before blowing fuses.
Troubleshooting can be a time consuming, frustrating and dangerous even if you do have any electrical knowledge.
Good Luck
Bob
__________________
2014 Flagstaff 206LTD
2008 Nissan Armada LE 4X4 TV
Amateur Astronomer Golf
Retired Electrical Engineer
|
|
|
07-15-2019, 11:04 PM
|
#14
|
Junior Member
Join Date: Jul 2019
Posts: 4
|
Wow! I am amazed at everyone’s willingness to take the time to post suggestions to try and help us. We are going to go ahead and replace all the interior light bulbs to make sure there is nothing causing a problem there. It can’t hurt and is relatively easy to do. The folks that replaced the roof want us to bring the camper in so they can check for a pinched or loose wire etc. They are quality people and trustworthy. We will still camp this weekend and just use other temporary lighting as needed during the night. On the way home we plan to drop the camper off for them to check and asses wiring.
We will let you know what is discovered and hopefully report a good outcome.
Again thank you for everyone’s willingness to help.
__________________
Gary
2008 FlagStaff 625D
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Discussions |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|