Forest River Forums - Animegodfather's Album: My Camper Roof Repair

Home
Forums
Classifieds
Photos
Registry
FRF Google

		Forest River Forums > Animegodfather's Profile > Albums
My Camper Roof Repair

Registry

Page 1 of 2

My Camper Roof Repair

My camper I bought it needed some repair new winch cable and roof repair the side boards were rotted out as well as the boards on the ends of the curve of the roof.

as you can see i removed the beds and rails and slider rail holders...with these removed and the roof on at lowest highth I simply took measurements...

WEll looky there it fits...still not mounted though. IF you look you can see i removed the beds and the bed trays there is a reason for this!!!

initial checks and mock ups after remounting the panels

Hmm this roof seems to be upside down....lol

new front board back went about the same....just one thing i will say...>CLAPS>>>>>>NEEED MORE CLAMPS

hmmm i found one of the leaky cuplrits that caused all this damaged...more EPOXY!!! seal every hole you find from the under side....lol

HMM if you are doing this project I highly recommend calling the manufacture and getting a pair of these. FACTORY made side board...

WOOPS i goofed was cutting and well went a little deep ...no problem..EPOXY!!!!!! lol

slowly getting where I wanted . The red circles were damaged areas where I was going back with epoxy to repair the underside

yup had to remove the whole back peace that was the rear beam/brace and a section of the side as well. There was just to much rot

not to shabby if I say so ...and yes the other two pictures are the back and this is the front but they both turned out about the same

peeling each layer of bad wood off layer at a time...so i could save the underlying roof membrane

Well the roof is proped up so i can remove the A/C unit

After alot of work hey there is a roof again

Page 1 of 2

Disclaimer:

This website is not affiliated with or endorsed by Forest River, Inc. or any of its affiliates. This is an independent, unofficial site.

All times are GMT -5. The time now is 10:17 AM.